Toyota Motor Maintenance Cases and Comments Catalogue

Chapter 1 Engine Maintenance Case 1

Section 1 VIOS series 1

I abnormal noise of VIOS engine 1

Second, the idle speed is high after cleaning the throttle.

Three, VIOS engine start time is too long 4

Section 2 Corolla Automobile Series 5

1. Abnormal engine noise when Corolla cold car starts 5

Second, the Corolla engine fault light is on, and the vehicle cannot accelerate 7.

Third, the Corolla cold car can't start seven at a time.

Four. Corolla engine jitter 8

Five, Corolla cold state engine serious jitter can't run normally 9

The intransitive verb Corolla EX runs at low speed 10.

Section 3 Corolla Automobile Series 15

First, Corolla cannot start 15.

Second, the engine fault light is on 17.

3. Abnormal noise of Corolla idle throttle 18

Iv. corolla idle speed 19.

Verb (abbreviation of verb) Abnormal noise of Corolla engine 20.

6. The engine noise of Corolla is 2 1 when it is automatically shifted and accelerated.

Seven. Corolla turns 2 1 and then accelerates.

The fourth quarter reiz automobile series 27

1. Due to the damage of Reiz three-way catalytic converter 27, the engine fault light is on.

Second, the Reiz engine accelerates slowly, and the engine warning light, VSC and skid indicator light are on 29.

Three. Reiz engine fault light is on (1) 30

Four, reiz engine fault light (2) 3 1

Five, reiz engine fault light (3) 32

Six, Reiz oxygen sensor crash caused engine failure, the light has been on and the electronic fan has been turning 34.

Seven. Reiz sometimes does not respond when it starts normally.

Eight, reiz engine abnormal noise when accelerating 36

Nine, reiz acceleration weakness 37

Section 5 Crown Car Series 42

A, the crown block coolant temperature alarm 42

Second, the crown has poor acceleration, and the sudden acceleration and flameout are 43

Three. Abnormal starting noise of Crown Engine 45

Fourth, the fault light of Crown Engine has been on for 45 hours.

Five, COVID-19 engine fault light 46

Six, Crown Engine Idle Jitter 47

Seven, crown idle jitter, acceleration weakness 48

Eight, the crown GRS 182 valve ablation fault 50

9. Abnormal oil consumption of Crown Engine 5 1

X. The fault light of Crown Engine is always on 54

Xi。 Engine flameout during crown driving 55

Section 6 RAV4 automobile series 57

I. RAV4 Abnormal sound in the cockpit 57

Second, RAV4 flameout while driving, the engine can't start 57

Three, RAV4 vehicles suddenly unable to accelerate at high speed 58

Section 7 Prado car 59

I. Abnormal sound of Prado engine 59

Second, the rocker arm of Prado 2700 engine falls off, making it difficult to start the engine.

Three, Prado 2700 engine rocker arm off 62

Four, Prado flameout while driving (1) 63

Five, Prado flameout while driving (2) 64

Six, Prado flameout while driving (3) 65

Seven, 20 1 1 Prado engine idle jitter 67

Eight. Prado GRJ200 68 has poor acceleration.

Nine, Prado 4000 engine can't start 72

X. Prado 72 has poor acceleration

Eleven, Prado acceleration weakness 73

Twelve, Prado engine high speed weakness, exhaust pipe shooting 76

Thirteen, Prado 4000 engine can't start normally 79

Fourteen, Prado 4000 engine idle jitter 8 1

Section 8 Land Cruiser Car Series 86

1. The exhaust pipe of the Land Cruiser 4500 was damaged, the exhaust pipe was shot, and the exhaust pipe burned red.

Second, the land cruiser FZJ 100 failed to accelerate, and the hot car stalled 87.

Three. Land cruiser LC200 anti-skid light, engine fault light and 4LO fault light are on 89.

Four, land cruiser 4700 engine 6 cylinder fire 9 1

Five, land cruiser 4700 fault light 93

Six, land cruiser 4700 engine fault light 94

Seven, land cruiser 4700 engine sometimes can't start 97.

Section 9 Other Cars 100

I. Abnormal sound of Costa engine 100

Second, the Prius engine can't start, and the vehicle runs 10 1.

3. Prius engine failed to start 108.

4. The Prius engine fault light is on, so the vehicle cannot enter the ready state at the same time, and the vehicle cannot run 1 14.

5. Camry 2? The power of the 4-liter engine is less than 1 15.

VI. Poor acceleration of Camry Expressway 1 17

Seven, Camry can't start 1 18.

Eight, Camry air-fuel ratio sensor failure led to engine acceleration weakness 1 19.

Nine, Lexus LS430 engine abnormal sound 123

X. The engine fault light is abnormally lit after Lexus driving for 40000km maintenance 124.

Eleven, Lexus LS430 engine warning light 126.

Twelve. Lexus GS300 engine 129 has poor acceleration.

XIII. Overlord can't accelerate 134

Fourteen Using exhaust back pressure gauge to judge exhaust blockage fault 140

Chapter II Chassis Transmission System Maintenance Case 146

Section 1 VIOS series 146

1. VIOS ABS fault light is on (1) 146.

2. VIOS ABS fault light is on (2) 147.

Section 2 Corolla Automobile Series 149

A. Carola's body trembled 149.

2. Corolla EX ABS fault light is always on 150.

Section 3 Corolla Automobile Series 150

First, the Corolla fault light is on, and the transmission cannot enter the overdrive gear 150.

Second, Corolla occasionally turns without assistance in the process of starting 152.

Iii. Corolla's steering power failure during driving 153

Four. Corolla's brake pedal is very soft, abnormal sound 154.

Five, Corolla parking brake cable icing 155

6. Corolla had an accident while turning, and it was suspected that the vehicle accelerated automatically and could not control the vehicle 156.

Seven, Corolla transmission oil temperature sensor failure 159

The fourth quarter reiz automobile series 160

1. The fault lights of Reiz ABS and VSC are on 160.

Second, Reiz sometimes can't shift gears 16 1.

3. Reiz engine fault light, VSC and sideslip indicator light are always on 162.

4. Abnormal sound of Reiz tire parts in the right direction 163.

V. Abnormal steering noise of Reiz 163

When the intransitive verb Reiz (164) brakes at high speed, there is abnormal noise at the tail.

Vii. Reiz fault light, gear impact 165.

Eight, reiz ABS fault light 167.

Section 5 Crown Car Series 168

1. When Crown is driving, the ABS and VSC fault lights are on 168.

2. The electromagnetic valve of Crown SL2 is stuck, which makes the transmission unable to upshift 169.

3. When the Crown decelerates, the car body rushes 170.

Iv. Gear lock failure of crown block 172

5. Crown lightly steps on the brake pedal when the vehicle speed is about 20km/h, and the right front wheel has abnormal sound 172.

Six, COVID-19 steering abnormal sound 174

Seven, Crown 3? 0L No electric power steering 175

Eight. Crown drive jitter 178

Section 6 RAV4 automobile series 183

1.RAV4 ABS fault light, anti-skid light and parking brake light are on 183.

Two. RAV4 chassis abnormal noise when driving on bumpy road 184

3.RAV4 brake lights are off, ABS and VSC lights are on 184.

Section 7 Prado automobile series 188

1 .prado 4000ABS, TRC and VSC fault lights are on 188.

2. Abnormal sound of Prado's right rear brake shoe on bumpy road 189

3. The warning light of Prado 4000ABS is on 192.

Four. Prado air suspension 193 works abnormally.

Section 8 Land Cruiser Car Series 195

1. ABS, VSC, TRC and anti-skid indicator light occasionally light up when the land cruiser 4700 is braking while driving 195.

Second, the warning lights of the new car brake of the land cruiser LC200 and the warning lights of VSC and TRC are all on 196.

Iii. The chassis of the land cruiser rises and falls abnormally 197

Four, land cruiser 4700 engine fault light 198.

5. The skid indicator and VSC indicator are on, and the ABS system will automatically turn on 20 1.

Section 9 Other Cars 208

1. Camry's water inflow caused the transmission filter to be blocked, so it was impossible to shift gears.

2. Camry ABS moves abnormally when braking at low speed 2 10

III. Camry Zhuanzhong 2 16

4. The speed of Previa is above 80km/h, and the vibration of the car body is 2 17.

Verb (abbreviation of verb) Abnormal noise at the front when the speed of Previa is above 140km/h and braking is above 2 17.

Chapter III Case of Body Electrical Maintenance 222

The first quarter VIOS car series 222

A, VIOS radio bad 222

Second, VIOS remote control failed, and the indoor lights did not light up.

Three, VIOS air conditioning compressor does not work, AC light flashing 224.

Four, VIOS burglar alarm doesn't work 226

In the second quarter, Corolla automobile series 227

A, corolla instrument vibration occasionally lights up 227.

Second, Corolla air conditioning system leaks fluorine and does not refrigerate 227

Three. Corolla EX Remote Control Fault 228

Fourth, the remote control failure caused by the water leakage of the Corolla windshield. 230

V. Damage to the temperature sensor of Corolla evaporator leads to poor air conditioning (repeated inhalation) 232

In the third quarter, Corolla automobile series 233

First, sometimes the Corolla radio is silent.

Second, the Corolla air conditioner doesn't work.

Three, Corolla battery power loss 238

Four. Corolla's four-door stopper has a serious abnormal sound when opening the door.

Verb (abbreviation of verb) When Carola uses the radio or MP3, the windshield heats up after opening, and there is an abnormal sound of 24 1.

6. After Corolla installed the navigator, the engine warning light came on 242.

Seven, corolla air conditioning blower occasionally don't work 243

Eight, corolla headlights can't automatically go out 244

The fourth quarter reiz automobile series 246

I. Reiz Air Conditioning Refrigeration 246

2. The defogging indicator flashes 247 before Reiz turns on the air conditioner defogging switch.

Third, Reiz sometimes fails to start 248.

Four, Reiz engine fault lights, VSC lights, anti-skid lights on, there is a big impact and noise when shifting 249

Five, reiz remote control door fault 25 1

Six, reiz remote control can only lock the car can't unlock 252

Seven, reiz high beam is not bright 253

Eight, reiz variable capacity compressor intermittent refrigeration 253

Section 5 Crown Car Series 258

A, COVID-19 battery leakage 258

Second, the new crown windshield interferes with the fixed hole iron plate, resulting in abnormal sound 260.

Third, the new crown roof abnormal sound 26 1

Four, crown air conditioning refrigeration 263

Verb (abbreviation of verb) Crown instrument bus short circuit 264

Six, crown air conditioning panel failure can't use 268.

Seven, Crown Navigator can't receive GPS signal 269.

Eight, Crown original car navigator fault 272

9. The outer protective rubber strip (right side) of the new crown windshield is deformed, resulting in abnormal sound when the vehicle speed is above100 km/h/h..

X. The automatic separation and reset function of Crown electric tilting telescopic steering column sometimes doesn't work.

Eleven, crown air conditioning compressor using inferior compressor oil damage 276

Twelve, the crown remote control sometimes can't use 278.

Thirteen, Crown 3? 0L Engine Shutdown System Fault 280

Section 6 RAV4 automobile series 282

1.RAV4 Remote locking and unlocking the door does not work. 282

Two, RAV4 air conditioning mode conversion has a "click" sound 283.

Three, RAV4 generator does not generate electricity 285

Four. RAV4 Electric power steering, airbag and ABS warning lights illuminate 286

Five, RAV4 engine suddenly unable to start 288

The intransitive verb RAV4 the glass of the left front door leaves the groove when it is lifted.

Seven. The RAV4 brake light is always on due to water leakage from the right front windshield 289.

Eight, RAV4 engine can't start 29 1

Nine, RAV4 engine fault light alarm 294

X.RAV4 navigation display screen has no phone icon display 296.

Section 7 Prado automobile series 299

Prado 4000 blower does not run 299

2. When Prado is driving in rainy days, there is water 300 on the front passenger seat mat of the cab.

3. The evaporation box in front of Prado air conditioner leaks 30 1

Fourth, Prado can't remotely control the vehicle 302 by activating the remote controller.

Verb (abbreviation of verb) Prado generator 304 generates electricity abnormally.

Six, Prado key warning buzzer failure 307

Seven, Prado air conditioning does not cool 307

Section 8 Land Cruiser Car Series 309

First, the right rearview mirror of the land cruiser LC200 cannot move up and down 309.

Second, the land cruiser 2700 engine can't start 3 1 1.

Section 9 Other Cars 3 14

1. Abnormal power supply of Costa 3 14 jumper leads to the instrument not displaying.

Two, Lexus 430 air conditioning system failure 3 15

Iii. Abnormal movement of Lexus LS430 right front rearview mirror 3 18

Four, Previa remote control failure 320

Verb (abbreviation of verb) Prius driver's door intelligent unlocking function failure 322

Six, Prius can't start normally 323

Seven, Previa electric car door can't be opened by remote control 326

Eight, the new Previa fault lights up, and the electric door doesn't work.

Nine, sea lion new car can't start 332